Margin for recessed, tempered glass table top

Joined
Jul 30, 2023
Messages
23
I have made an end table out of walnut. The pieces are 1 1/2” square and the interior space is 15 inches by 15”. I have cut a 1/4 by 1/4” Rabat to hold a recessed tempered glass top (1/4 inch thick glass). Right now I’ve cut a blank with plywood that fits perfectly snug. Should I have glass made for this exact same size, or go a bit smaller to allow for wood expansion? How much smaller should the glass be?

Thank you
 
Add 1/16 to the rabbit, this will give you 1/32nd per edge. The 1-1/2” pieces will not move much.

Tom
 
I have made an end table out of walnut. The pieces are 1 1/2” square and the interior space is 15 inches by 15”. I have cut a 1/4 by 1/4” Rabat to hold a recessed tempered glass top (1/4 inch thick glass). Right now I’ve cut a blank with plywood that fits perfectly snug. Should I have glass made for this exact same size, or go a bit smaller to allow for wood expansion? How much smaller should the glass be?

Thank you

Without an explanation of which way the grain is running, I can't make an intelligent comment.

Except that you are likely overestimating the precision of the glass company cutting. For a close fit, you really can't cut the rabbet without having the glass in-hand.
 
Without an explanation of which way the grain is running, I can't make an intelligent comment.

Except that you are likely overestimating the precision of the glass company cutting. For a close fit, you really can't cut the rabbet without having the glass in-hand.
I agree.

Except cutting the rabbet may not have been the best approach.

Putting four 3M Bump-ons, one in each corner will prevent the glass from creeping and there will be no accumulation of dirt in the rabbet around the glass.

You might just want to rip it down flush and get the bump-ons. They are inexpensive, about 1/2” in diameter and about 0.100” thick with a very good adhesive. The adhesive will bond with the wood. The glass naturally has a high level of friction with the resin they use in the Bump-ons. If you enlarge the image below, the package lists the actual dimensions (metric).

In my opinion, the glass should overhand the table base by at least 1/4”. It is way easier to clean glass, than to re-finish the base.

When I get home, I will measure the thickness of the glass table top I have and also the glass coffee table top I have. I will post the dimensions when I have them.

Addendum: I measured the thickness of the glass table tops I have. The store-bought table has the glass sitting on a wooden base in a cross pattern. Thickness: 0.378”. Table size: 42” round. Overhand (at 4 points): 4-1/2”.

Coffee table, shop made: 0.380” thick, 1” overhang. Resting on four 3M Bump-ons, one in each corner.

Two points worth noting: It is possible that both glass tops are the same thickness. The deviation of 0.002” thickness might be a result of poor measuring technique.

The second point, possibly of greater importance is the fact that the glass top on the coffee table has appeared to have bonded to the bumpons. That is not how they are supposed to work. I have not removed the top from the base since I built the coffee table (about 27 years ago), and I assume that the soft resin in the bumpons has bonded. The resin appears to be similar to what is used on suction cups. I will have a go at them with a razor blade when the mood overtakes me.

But the dining table top does lift off and that is only about 15 years old. Apparently I should clean both side of the glass from time to time.

My introduction to Bumpons was from my picture framing days. Two were added to the bottom corners to keep the frame from shifting against the wall and from marking the wall at the contact points.

1768486911059.png
 
Last edited:
I inherited a couple end tables with marble tops inlaid like the OP describes, except the marble was thick enough that they stuck up about ¼" beyond the frame, but fit the frame pretty closely - less than 1/32" gaps. The wood tables were ugly, so I just kept the marble but have yet to build something around them.

I have glass tops on a Louis Vitton trunk that we use as coffee table. Due to all the wood webbing, I have thick clear bumpers at the corners, but the glass top was sized to match the outside of the trunk, so no real overhangs nor recesses (but yes, it's not exact, which doesn't matter given the space between them). That top is ½" thick.

I also have ⅜" thick glass tops on two drawer units in our bathroom whose tops are just a bit bigger than the OP's, and they look/function fine.
 
Back
Top