Entry hall table for a niece

Very Nice Derek! I use eucalyptus a lot. Very similar to the Jarah you are using if not the same thing. It grows huge here in Arizona so it's what I use most. Can be difficult to work sometimes, very dense and brittle. Beautiful stuff.

Looking forward to seeing the figure on that piece when the finish goes on. Very well done on the mitered dovetailed corners as well. Great build.
 
Okay, so I decided that the wood screws were a mistake. They would prevent movement rather than permit it. So they had to go.

This is the exchange screw: a 12 gauge stainless steel wood/metal screw with an all-important flat/domed head.

1a.jpg


The plan was to use a 3/4" forstner bit. This would leave a wide, flat area for the screw head to move along. The range of movement would be the same as before, about 2mm each side of the screw.

A MDF template was made to guide the forstner bit, as it had no support in view of the existing hole ...

2a.jpg


Drilled to depth ...

3a.jpg


A steel washer added ...

4a.jpg


Done ...

5a.jpg


I had only 15 minutes after work today, but on the weekend, when I get back to this build, I plan to add a third screw behind the front leg.

Regards from Perth

Derek
 
I put the last screws in after work. That will free up this weekend to concentrate on building the drawers.

There are three screws. The one at the toe is fixed and there is no play for any movement. The two at the rear can slide 2mm each way.

1a.jpg


2a.jpg


Regards from Perth

Derek
 
This is the part where we begin building one-piece lipped drawers (as contrasted with applied fronts).

In preparing for this part of the build, my research uncovered exactly one article on dovetailing lipped drawer fronts. This is by Christian Becksvoort in Fine Woodworking magazine (#263-Sep/Oct 2017 Issue). Interesting that.

Why lipped drawer fronts? Simply because the three drawers must run continuously across the front, without a gap between them.

11a.jpg


The lipped sides will wrap around the drawer dividers, and these will double as drawer stops. This will be illustrated in a short while.

The lipped ends create a challenge to form the pins/sockets for the tailed drawer sides since it becomes difficult to saw. I have a novel solution :)

We begin by marking where the lipped sides will be. This is knifed in through from the rear of the case ...

Drawer2a.jpg


The marks are knifed with a cutting gauge.

The distance from the edge is exactly the same for each board - 6mm. The side spacers are 6mm wide and the two central drawer dividers are 12mm thick, of which each lip is half this thickness.

Drawer5a.jpg


The drawer front is rebated with a moving filletster plane ...

3a.jpg


With both sides rebated, the centre must fit snuggly between the drawer dividers ...

4a.jpg


... and leave exactly half of the dividers remaining ...

5a.jpg


6a.jpg


Side-by-side, perfect fit ...

7a.jpg


The rebates are fine-tuned with a cutting gauge, ensuring that they are even and square ...

1a.jpg


This measure is transferred to the drawer side ...

2a.jpg


I took the time to lay out the dovetails on a scrap as a template. This saves a lot of repeated layouts ...

3a.jpg


Tails done ...

4a.jpg


The tail board with be placed here, but with the lip extending past ...

5a.jpg


This is what it would look like if dovetailed ...

6a.jpg


To make it easier to see what I am sawing, I am using blue tape ...

7a.jpg


Transferring the tails to the pin board is made a little easier as the rebate is a handy stop ..

8a.jpg


9a.jpg


Marked out produces this ...

11a.jpg


And that is where it stops being straight forward as this is as much as it is possible to saw inside the lines ...

12a.jpg


I decided that, if I could not saw it, I would chop it. This gives new meaning to "chopping dovetails" :)

The pin board is clamped (to avoid any splitting), and the kerfing chisel is used to deepen the existing half-kerf, and then extend it across the socket ...

14a.jpg


15a.jpg


Now the waste is chopped out ...

16a.jpg


17a.jpg


This picture of a fishtail chisel cleaning the corner of the socket is for bill :)

18a.jpg


Does it fit? Oh, the suspense!

19a.jpg


20a.jpg


Two more to go.

Regards from Perth

Derek

 
Today I completed the second and third drawer fronts ...

7a.jpg


Since I had only come across one article on making the lipped drawers - and that predominantly used power tools - and failed to find a single video on the topic, I decided to make one myself:


This is a real-time video - no editing. So skip the parts as they bore you. Hopefully some of it will amuse. Or watch at bedtime if you are insomniac :)

Regards from Perth

Derek
 
The build is nearing the conclusion. The drawers, case back, and finish to do. Here, the drawers are continued. The focus of this article is on fitting the drawer (with lipped sides), and the fixtures that are used in the course of this process.

We ended the last build session with the drawer parts made ...

EntryHallTableForANiece11_html_5222b26b.jpg


... and the lipped drawer fronts completed ...

EntryHallTableForANiece12_html_1433a67d.jpg


First task today was to plane the groove for the drawer fronts ..

1a.jpg


The drawer sides and drawer back were dovetailed ... simple through dovetails. The notable feature here is that space is left for the drawer slip (which replaces the drawer groove as the drawer sides are 1/4" thick).

Of interest may be the bench hook I use. I suspect that some may look at this and wonder why I am butchering it by chopping on its top ..

7a.jpg


4a.jpg


Well, it is just scrap, and took about 5 minutes to make. So far this one has lasted about 3 months. I should get a few more out of it.

Not only is it used for chopping, but also sawing ...

6a.jpg


... and even shooting ...

5a.jpg


One of the issues with a lipped front is that it cannot be planed to fit after glue up. So, there are lots of dry fitting, and the sides are planed individually. This planing stop is invaluable for thin boards ...

8a.jpg


End-stop1.jpg


There is non-slip in the form of Crubber on the face of the stop ...

End-stop2.jpg


When fitted together, any raised pins need to be pared level. Here, the drawer is captured in a fixture (essentially, two pieces of ply, each with a cut out). The pins are pared with the newly-released Veritas flushing chisels ...

9a.jpg


I've had a pre-production set for a couple of years. This is what a prototype handle looks like ...

2.jpg


Veritas now supply this in a nice wooden handle. The one I am using is a design of my own, ala a Japanese slick ..

Chisels4_zpsvbyw2nls.jpg


Fitting the drawers also required positioning and glueing the drawer dividers. These also act as drawer stops ...

This is the drawer divider in position ...

10a.jpg


It is slid back ...

11a.jpg


The first third of the dado receives glue ...

12a.jpg


The drawer is replaced and positioned ..

13a.jpg


And then the drawer divider is slid up against the rear of the lip ..

14a.jpg


The drawer case is fine-tuned with the LN Rabbet Block Plane ...

15a.jpg


This is used to smooth over any irregularities in the side walls and, where necessary, to plane away any fat ...

16a.jpg


The drawers are in the process of being glued up. Drawer #3 cannot be glued up until a brass plate is recessed  into one side. T

17a.jpg


Marked out, the waste routed, and then chiselled along the circumference ...

18a.jpg


19a.jpg


The drawer fronts are planed ...

20a.jpg


Another dry assembly and check for fit ...

22a.jpg


If there is any resistance to the drawer being pushed in-and-out, I test fit it from the rear. This shows whether the drawer or case needs some planing. Looking good here, as it goes right in ...

23a.jpg


There is good drawer extension (about 80%) ...

24a.jpg


The drawers are now glued up.

Lastly, for the day, the slips are attached. These began like this, grooved and beaded ...

20a.jpg


A Jarrah runner is added below. The upper section of the slip is, as with the drawer sides and drawer bottoms, made from Tasmanian Oak. This is similar to US White Oak in hardness and wear. Since the drawers run on Jarrah, the wear properties are improved with the Jarrah wear section ...

26a.jpg


Tomorrow should see the conclusion of the build.

Regards from Perth

Derek
 
Really, really nice, Derek!  I especially think the plaque is a nice touch.  Can't wait to see the finished pics!
 
This is the last part of the build - completing of the drawer bottoms and pulls.

A panel was prepared some weeks ago. 1/4" thick Tasmanian Oak. This was made up of two, book matched boards. Blue tape was used to pull the jointed edges together. Clamps are unnecessary for this task ...

EntryHallTableForANiece11_html_5222b26b.jpg


Measure off the full width of the drawer bottom from inside the slips ...

2a.jpg


Of possible interest is the work holding for the drawer bottom ...

3a.jpg


The bench dogs on each side were made from sections of unhardened O1 steel, and filed into teeth.

4a.jpg


Another heads-up is the arm for this cutting guard. Some while back, Veritas brought out a gauge with a fine adjuster. They now sell the arms to upgrade existing gauges, which is what I have done here to a wheel gauge I made ...

5a.jpg


Here the tongue is marked (about 4mm). This will fit into the groove in the slip.

The thickness of the tongue is marked (3mm).

6a.jpg


The tongue is planed ...

7a.jpg


The fit is tested with a spare slip ...

8a.jpg


The bottom was about 1mm too wide to fit. A LN edge was perfect to re-joint one side ...

9a.jpg


Re-establish the tongue with a shoulder plane ...

10a.jpg


Slide the bottom in. At this time it is just a dry fit. The front, which remains 1/4" thick to fit to 1/4" groove at the rear of the drawer front, is not yet pushed home. The front groove will hold the one end firmly, allowing movement towards the rear of the drawer.

11a.jpg


The drawers require pulls. The aim is to make the pulls "vanish" as much as possible. To do this, the shape is kept simple, and the wood is a section from the drawer fronts. Here it is being planed to 1/4" thickness.

12a.jpg


Set up to make the pulls ...

13a.jpg


A 10mm wide rebate is planed on both sides. This will be completed on the reverse side as well, to create a tenon 3mm thick.

14a.jpg


Four sections are marked off for the pulls (only three are needed) ..

15a.jpg


A router is used to create dimples for a finger grip on the underside of the pull  (three were needed and were good here; one could be tossed) ...

16a.jpg


17a.jpg


The outlines are cut out ...

18a.jpg


The router is again used, this time to create a 3mm x 50mm mortice in the drawer fronts for the pulls  ...

19a.jpg


The final section of the build is the drawer back. I decided to use Jarrah to match the rest - one never knows whether the hall table will become a room divider.

The newly-purchased JessEm Clear-Cut TS Stock Guides make a clean, accurate rip that much easier  ...

20a.jpg


The next post will show the completed hall table.

Regards from Perth

Derek
 
Beautiful!

Nice to see the MOF-177 earning it’s keep, I have one in good order that mainly sits in a router table. The other is brand new unused in it’s original box, on a shelf in the workshop (at least 30 odd years old)
I don’t know why we never used it? I think I bought two together and a recession hit, so work volume slowed, and it’s sat there ever since.
As you know, they’re are great routers.
 
JJ, the Elu177e is an excellent router. That one was purchased 30 years ago. I do have another in a router table ..

Router-Raizer-2.jpg


Router_Raizer_1.jpg


As you are probably aware, today these are sold as the DeWalt DW625.

Regards from Perth

Derek
 
Hi Derek, yes I’ve bought a few parts (dust extraction port etc) under the De Walt DW625 listing.
Still prefer Elu grey to De Walt yellow though  [wink]
 
My niece is getting married at the end of March, the entry hall table she asked for is completed, and in a couple of days it will head off to Sydney.

This is the model for the table she wanted me to build, but to build it in Jarrah ...

Jes-Entry-Table.jpg


I needed to make a few modifications. The most notable were, firstly, that there are three drawers, where the model has two. With a little research, it became evident that the model was a "flat pack" build from a store in the UK, and it used slides and poppers for the drawers. Without slides, wide drawers will rack since the depth-to-width ratio is all wrong. Three drawers change this ratio and make it workable.

Secondly, building a drawer to ride wood-on-wood, one cannot use poppers - and so drawer handles are necessary. My niece was keen that drawer handles would not be seen, and I have done my best to make them unobtrusive.

Together with the desire to avoid drawer handles, there was also the request to make the drawers appear to be a single piece, rather than drawers separated by drawer dividers. The fact is, we had to have drawer dividers. So, to hide them, drawer fronts were given lips, with a lip covering half the width of a divider. In this way, the dividers could double as drawer stops. Making lipped, half-blind dovetails was a first for me. In the end, they were not too bad.

The case of the original table is mitred, and this is likely butt jointed and supported with either dowels, biscuits or dominos. My choice was to use mitred through dovetails, both for their strength and also for aesthetics. Although I have done a number of similar cases in recent years, this joint is one where you hold your breath until it all comes together. Then you wonder what the fuss was about :)

A fifth change was the attachment of the legs. The model likely used a metal screw per leg, which was common with Mid Century furniture. I wanted something stronger and durable so, in place of this, my decision was to stake the legs into a thicker base, which was firmly attached to the underside of the case with tapered, stopped sliding dovetails. A bit more work, but I will sleep better at night.

At the end of the day, it resembles a box, and only a woodworker will recognise that it is a very complex box. :)

Okay, here it is. It is photographed in my entrance hall  ....

1a.jpg


The wood is fiddleback (curly) Jarrah.

2-1a.jpg


3a.jpg


A close up the waterfall on one side ...

4a.jpg


... and on the other ...

5a.jpg


The obligatory dovetail shot ...

6a.jpg


Those drawers! The lipped drawer fronts are 20mm, with the drawer sides 1/4". The back is 15mm thick. The thin sides necessitated drawer slips. These were beaded to create a transition from slip to drawer bottom. The drawer bottoms are 1/4". The wood used here is Tasmanian Oak.

7a.jpg


8a.jpg


9a.jpg


10a.jpg


Since the case and internals are build from hard Jarrah, the underside of the slips was given a Jarrah slide to improve ware properties.

12a.jpg


As mentioned earlier, the aim was to present a single board at the front ...

15a.jpg


Here may be seen how the lips share the drawer divider and use it as a drawer stop. The spacers at the side of the case are half the width of the dividers as they do not share two drawers.

17a.jpg


18a.jpg


Now those drawer handles ...

I tried to keep the design as simple as possible, and used the same wood as the drawer fronts so they would blend in. The upper drawer shows the finger grip on underside of the handle ...

19a.jpg


Drawer extension is good - about 80-85 percent ...

21a.jpg


The internal bevels around the case ...

22a.jpg


... maintained a straight edge to the drawer line. Plus the gap between the drawers (about 0.5mm) ...

24a.jpg


Near-to-last, the case back: this is made from the same Jarrah - one never knows if the piece will end up against a wall or out in the open.

13a.jpg


Someone will ask if the brass screws were clocked ... of course they were! :)

And a final photo to provide some scale. This is taken with a chair I built a few years ago ...

25a.jpg


Thanks for coming along for the ride.

Regards from Perth

Derek

 
Derek, that really is a work of art, and demonstrates a lot of techniques and fine detail.
It will be loved and admired for many years to come, without doubt. It reminds me of some pieces I saw at an exhibition a few years back.
There were pieces, that the more you looked at, the more detail and craftsmanship you uncovered. Very much like your table.

I will show it to my old retired cabinet maker friend, he will really appreciate the detail.
[thumbs up]
 
Thanks Jiggy for all your kind words and encouragement. I welcome the critique of your friend.

Regards from Perth

Derek
 
Derek, Your niece is a very fortunate lady to have you as an uncle. Beautiful work, thank you for sharing the project.
 
Hi Derek,

That is an exceptionally nice piece. Just gorgeous. I'm sure your niece will cherish it.  I hope some day to reach a skill level approaching yours. And thank you for taking the time to document the build. Your photos and explanations are superb. I really appreciate the effort.

Many years ago I made several business trips to your side of the country. On one trip I happened into a home center down in Collie and was amazed to see Jarrah being offered for deck boards. Over here the stuff is rare and precious. It is truly beautiful. 

Thanks again.
 
Derek,  All I can say is, this thread is akin to when I discovered my first Playboy as an adolescent.  Woodworking porn!  You are The Man.  Cheers!
Jim
 
Back
Top